Publicação
Monitoring the thermal efficiency of fouled heat exchangers: A simplified method
| Resumo: | Fouling is a problem whether we are aware of it or not. In an industrial plant, it is important not only to be able to measure the buildup of unwanted deposits, but also to do it in the simplest and most economically possible way. This paper addresses the question of monitoring fouling in an oil refinery plant, where the high number of heat exchanger units and the variability of the feedstock charge pose additional problems in terms of the practicability of following the energetic performance of such equipment. In this case, the flow rates and quality of the fluids flowing through the heat exchangers do not usually correspond to the design conditions, because they change with time. Therefore, to assess the fouling level of the exchangers, the day-to-day measured thermal efficiency should not be compared with the efficiency predicted in the design calculations. The latter should be recalculated by introducing whenever necessary new values of flow rates, physical properties, and so forth, and by evaluating new heat transfer coefficients. However, the procedures are too time consuming to be applied frequently. The present work describes a simplified method for following heat exchanger performances, based on the assessment of the number of transfer units and thermal efficiencies, where the effects of changing the feedstock charge, particularly the flow rates of the fluids, are taken into account. The only data that need to be collected are the four inlet/outlet temperatures of the heat exchanger unit and one of the flow rates. Several heat exchanger units in an oil refinery were successfully monitored by means of this method, and it was found that the variations in the physical properties did not significantly affect the results obtained for the particular plant under study. |
|---|---|
| Autores principais: | Jerónimo, M. A. S. |
| Outros Autores: | Melo, L. F.; Braga, A. Sousa; Ferreira, P. J. B. F.; Martins, Carlos C. |
| Assunto: | fouling monitoring heat exchangers |
| Ano: | 1997 |
| País: | Portugal |
| Tipo de documento: | artigo |
| Tipo de acesso: | acesso aberto |
| Instituição associada: | Universidade do Minho |
| Idioma: | inglês |
| Origem: | RepositóriUM - Universidade do Minho |
Registos relacionados
article Simplified numerical simulation to obtain heat transfer correlations for stirred yoghurt in a plate heat exchanger
por: Afonso, I. M.
Publicado em: (2008)
por: Afonso, I. M.
Publicado em: (2008)
article Particle transport in fouling caused by kaolin-water suspensions on copper tubes
por: Melo, L. F.
Publicado em: (1988)
por: Melo, L. F.
Publicado em: (1988)
article Experimental analysis of a finless gas-liquid heat exchanger
por: Teixeira, J. Carlos
Publicado em: (2016)
por: Teixeira, J. Carlos
Publicado em: (2016)
category Thermal simulation of concrete dams during construction: effect of the heat exchange mechanisms
por: Ponce-Farfán, Cristian
Publicado em: (2019)
por: Ponce-Farfán, Cristian
Publicado em: (2019)
article Thermal behaviour of stirred yoghurt during cooling in plate heat exchangers
por: Fernandes, C. S.
Publicado em: (2006)
por: Fernandes, C. S.
Publicado em: (2006)
article Experimental study of an innovative elastomer-based heat exchanger
por: Souza, R. R.
Publicado em: (2023)
por: Souza, R. R.
Publicado em: (2023)
category Application of a diffusion-reaction model to biofouling in heat exchangers
por: Vieira, M. J.
Publicado em: (1998)
por: Vieira, M. J.
Publicado em: (1998)
article Comparison of two biocides – carbamate and glutaraldehyde – in the control of fouling in pulp and paper industry
por: Pereira, Maria Olívia
Publicado em: (2001)
por: Pereira, Maria Olívia
Publicado em: (2001)
article Simulation of stirred yoghurt processing in plate heat exchangers
por: Fernandes, C. S.
Publicado em: (2005)
por: Fernandes, C. S.
Publicado em: (2005)
article Laminar flows in chevron-type plate heat exchangers: CFD analysis of tortuosity, shape factor and friction factor
por: Fernandes, C. S.
Publicado em: (2007)
por: Fernandes, C. S.
Publicado em: (2007)
article Fouling of European freshwater bivalves (Unionidae) by the invasive zebra mussel (Dreissena polymorpha)
por: Sousa, Ronaldo Gomes
Publicado em: (2011)
por: Sousa, Ronaldo Gomes
Publicado em: (2011)
article Double-defense barrier design for anti-fouling separation membrane with the biological catalysis and hydrogel coating for dye/salt separation
por: Yang, Xue
Publicado em: (2025)
por: Yang, Xue
Publicado em: (2025)
article Friction factors of power-law fluids in chevron-type plate heat exchangers
por: Fernandes, C. S.
Publicado em: (2008)
por: Fernandes, C. S.
Publicado em: (2008)
article Overview on the hydrodynamic conditions found in industrial systems and its impact in (bio)fouling formation
por: Fernandes, Susana
Publicado em: (2021)
por: Fernandes, Susana
Publicado em: (2021)
article Geothermal heat exchanger’s temperature input sensor prediction based on deep learning modelling technique
por: Oliveira, P.
Publicado em: (2024)
por: Oliveira, P.
Publicado em: (2024)
article Surface interactions and deposit growth in fouling of heat exchangers
por: Oliveira, Rosário
Publicado em: (1993)
por: Oliveira, Rosário
Publicado em: (1993)
article Postsynthesis modification of a cellulose acetate ultrafiltration membrane for applications in water and wastewater treatment
por: Morão, A.
Publicado em: (2005)
por: Morão, A.
Publicado em: (2005)
article Fouling in heat exchangers: a study of the mechanisms of formation of kaolin deposits
por: Melo, L. F.
Publicado em: (1985)
por: Melo, L. F.
Publicado em: (1985)
article Treatment of textile wastewaters with dynamic membranes
por: Amorim, M. T. Pessoa de
Publicado em: (2006)
por: Amorim, M. T. Pessoa de
Publicado em: (2006)
article The role of concentration polarization in ultrafiltration of ovine cheese whey
por: Duarte, Elisabeth
Publicado em: (2011)
por: Duarte, Elisabeth
Publicado em: (2011)
article Experimental evaluation of green nanofluids in heat exchanger made oF PDMS
por: Nobrega, Glauco
Publicado em: (2024)
por: Nobrega, Glauco
Publicado em: (2024)
article An advanced cement-based geocomposite with autonomous sensing and heating capabilities for enhanced intelligent transportation infrastructure
por: Abedi, Mohammadmahdi
Publicado em: (2024)
por: Abedi, Mohammadmahdi
Publicado em: (2024)
category Bioindicators as a tool for monitoring and control biofilm reactors : a simplified approach
por: Coutinho, L.
Publicado em: (2007)
por: Coutinho, L.
Publicado em: (2007)
article Compact automotive thermoelectric generator with embedded heat pipes for thermal control
por: Pacheco, N.
Publicado em: (2020)
por: Pacheco, N.
Publicado em: (2020)
article Surface phenomena and hydrodynamic effects on the deposition of Pseudomonas fluorescens
por: Pinheiro, M. M.
Publicado em: (1988)
por: Pinheiro, M. M.
Publicado em: (1988)
rate_review Therapeutic plasma exchange-a practical guide
por: Pais, Mariana Dias
Publicado em: (2026)
por: Pais, Mariana Dias
Publicado em: (2026)
draft Efficiency in portuguese stock exchange indexes : runs tests and BDS statistics
por: Afonso, António
Publicado em: (1997)
por: Afonso, António
Publicado em: (1997)
groups Industry energy optimization: A case study in a biodiesel production site
por: Palmeira, José
Publicado em: (2012)
por: Palmeira, José
Publicado em: (2012)
groups Optimization of desalination heat exchanger`s geometries using bat-inspired techniques
por: Costa, D. M. S.
Publicado em: (2015)
por: Costa, D. M. S.
Publicado em: (2015)
article Are tomato plants co-exposed to heat and salinity able to ensure a proper carbon metabolism? – An insight into the photosynthetic hub
por: Rodrigues, Francisca
Publicado em: (2024)
por: Rodrigues, Francisca
Publicado em: (2024)
article Influence of heat pipe operating temperature on exhaust heat thermoelectric generation
por: Brito, F. P.
Publicado em: (2013)
por: Brito, F. P.
Publicado em: (2013)
article Stable graphene membranes for selective Ion transport and emerging contaminants removal in water
por: Sankar, Siva Nemala
Publicado em: (2023)
por: Sankar, Siva Nemala
Publicado em: (2023)
book Ohmic heating treatment
por: Vicente, A. A.
Publicado em: (2012)
por: Vicente, A. A.
Publicado em: (2012)
article Advancing infrastructure resilience: A polymeric composite reinforcement grid with self-sensing and self-heating capabilities
por: Abedi, Mohammadmahdi
Publicado em: (2024)
por: Abedi, Mohammadmahdi
Publicado em: (2024)
draft Monetary transitions in Cabo Verde : from the escudo zone to the exchange agreement with Portugal
por: Estêvão, João
Publicado em: (2020)
por: Estêvão, João
Publicado em: (2020)
groups Thermal and non-thermal orange juice pasteurization: the impact of ultrasound, thermosonication and heat treatment on S. aureus kinetic inactivation behaviour
por: Amir-Tahi, Akila
Publicado em: (2021)
por: Amir-Tahi, Akila
Publicado em: (2021)
article Heat-pipe assisted thermoelectric generators for exhaust gas applications
por: Gonçalves, L. M.
Publicado em: (2012)
por: Gonçalves, L. M.
Publicado em: (2012)
groups Thermal and non-thermal orange juice pasteurization: the impact of ultrasound, thermosonication and heat treatment on S. aureus kinetic inactivation behaviour
por: Amir-Tahi, Akila
Publicado em: (2021)
por: Amir-Tahi, Akila
Publicado em: (2021)
draft Inflation persistence and exchange rate regimes : evidence from developing countries
por: Bleaney, Michael
Publicado em: (2005)
por: Bleaney, Michael
Publicado em: (2005)
article Inflation persistence and exchange rate regimes : evidence from developing countries
por: Bleaney, Michael
Publicado em: (2005)
por: Bleaney, Michael
Publicado em: (2005)
Registos relacionados
-
article Simplified numerical simulation to obtain heat transfer correlations for stirred yoghurt in a plate heat exchanger
por: Afonso, I. M.
Publicado em: (2008) -
article Particle transport in fouling caused by kaolin-water suspensions on copper tubes
por: Melo, L. F.
Publicado em: (1988) -
article Experimental analysis of a finless gas-liquid heat exchanger
por: Teixeira, J. Carlos
Publicado em: (2016) -
category Thermal simulation of concrete dams during construction: effect of the heat exchange mechanisms
por: Ponce-Farfán, Cristian
Publicado em: (2019) -
article Thermal behaviour of stirred yoghurt during cooling in plate heat exchangers
por: Fernandes, C. S.
Publicado em: (2006)